Журналы →  Non-ferrous Metals →  2019 →  №1 →  Назад

Название Sorption concentration of ruthenium from sulfuric solutions
DOI 10.17580/nfm.2019.01.02
Автор Zotova I. E., Fokina S. B., Boduen A. Ya., Petrov G. V.
Информация об авторе

Saint-Petersburg Mining University, St. Petersburg, Russia:

I. E. Zotova, Post-Graduate Student
S. B. Fokina, Associate Professor
A. Ya. Boduen, Associate Professor
G. V. Petrov, Professor


Performed are the studies on sorption concentrating of ruthenium from sulfuric solutions at variant concentrations of sulphuric acid with the use of KU-2 (КУ-2) and EDE-10P (ЭДЭ-1ОП) cation-exchange and anionexchange resins as well as a CAD (KAД) activated charcoal. It was determined that the highest possible sorption of ruthenium on all the tested sorbents from solutions containing 20 mg/l of ruthenium is observed if concentrations of sulphuric acid are within the range of 80–100 g/l. The EDE-10P sorbent have the most ability to absorb ruthenium; degree of ruthenium extraction by this sorbent doesn’t exceed 18% at L : S = 3 : 1. It has been revealed that in the case of three sorbents each contacting with the solution done in turn, the aggregate sorption degree doesn’t exceed 43%. At that, changing the order of introducing the sorbents into solution doesn’t exert a noticeable influence over the indices of ruthenium extraction into each sorbent type. It is suggested to carry out a preliminary recovery treatment of solutions in order to raise the degree of ruthenium extraction. It is shown that degree of ruthenium sorption by activated charcoal after the preliminary treatment of solutions by sodium sulfite is about four times more, that by anionite is half as much again and practically has not been changed in the case of sulfonic cation-exchange resin usage. A successive sorption by the tested sorbents from the sulfuric solutions treated with sodium sulfite guarantees almost complete extraction of ruthenium.

Ключевые слова Sorption processes, sorption concentration, platinum group metals, ruthenium, sodium sulfite, sulfuric solutions
Библиографический список

1. Petrov G. V., Shneerson Ya. M., Andreev Yu. V. Extraction of platinum metals during processing of chromium ores from dunnite deposits. Journal of Mining Institute. Vol. 231. pp. 281–286.
2. Chanturiya V. A., Kozlov A. P. Platinum-bearing dunnite ores and their enrichment. Moscow : URAN IPKON RAN, 2009. 148 p.
3. Melnichuk M. S., Fokina S. B., Boduen A.Ya., Petrov G. V. Co-recovery of platinum-group metals and chrome in processing of low-grade dunnite ore material. Obogashchenie Rud. 2018. No. 1. pp. 50–55.
4. Greiver T. N., Shneerson Ya. M., Goncharov P. A. Hydro metallurgical methods of the platinum metals recovery from the ores, concentrates and semiproducts. Khimicheskaya Tekhnologiya. 2003. No. 12. pp. 34–38.
5. Hubicki Z., Wawrzkiewicz M., Wójcik G., Koodyska D., Woowicz A. Ed. by A. Kilislioglu. Ion exchange — studies and applications. Chapter 1: Ion exchange method for removal and separation of noble metal ions. Rijeka : InTech, 2015. 35 p.
6. Borbat V. F., Shindler А. А. Chemistry and chemical technology of platinum group metals : a textbook. Omsk : OmGU, 2008. 176 p.
7. Mamyachenkov S. V., Adryshev A. K., Seraya N. V., Khairullina A. A., Daumova G. K. Nanostructured complex sorbent for cleaning heavy metal ions from industrial effluent. Metallurgist. 2017. Vol. 61, No. 7–8. pp. 615–623.
8. Timofeev K. L., Maltsev G. I., Usoltsev A. V., Naboichenko S. S. Sorption technology of recovery of indium from solutions of zinc production. Russian Journal of Non-Ferrous Metals. 2017. Vol. 58, No. 3. pp. 225–230.
9. Miroshnichenko A. A. Sorption recovery of platinum metals from compound solutions. Procedia Engineering. 2016. Vol. 152. pp. 8–12.
10. Nikoloskii A. N., Ang K. L., Li D. Recovery of platinum and rhodium from acidic chloride leach solution using ion exchange resins. Hydrometallurgy. 2015. Vol. 152. pp. 20–32.
11. Morcali M. H., Zeytuncu B. Investigation of adsorption parameters for platinum and palladium onto a modified polyacrylonitrile-based sorbent. International Journal of Mineral Processing. 2015. Vol. 137. pp. 52–58.
12. Ricoux Q., Méricq J. P., Bouyer D., Hernandez-Juarez L. C., Faur C., Bocoki V., Van Zutphen S. A selective dynamic sorption-filtration process for separation of Pd(II) ions using an aminophosphine oxide polymer. Separation and purification technology. 2017. Vol. 174. pp. 159–165.
13. Pechenyuk S. I. Sorption hydrolytic precipitation of platinum petals on inorganic sorbents. Leningrad : Nauka, 1991. 246 p.
14. Ehrlich H. V., Buslaeva T. M., Maryutina T. A. Trends in sorption recovery of platinum metals: a critical survey. Russian Journal of Inorganic Chemistry. 2017. Vol. 62, No. 14. pp. 1797–1818.
15. Mokhodoeva O. B., Myasoedova G. V., Kubrakova I. V. Sorption preconcentration in combined methods for the determination of noble metals. Journal of Analytical Chemistry. 2007. Vol. 62, No. 7. pp. 679–695.
16. Kononova O. N., Duba E. V., Schneider N. I., Pozdnyakov I. A. Sorption recovery of palladium (II) and platinum (IV) from hydrochloric acid solutions. Journal of Siberian Federal University: Chemistry. 2018. Vol. 11, No. 1. pp. 6–17.
17. Ginzburg S. I., Ezerskaya N. A., Prokofieva I. V., Fedorenko N. V., Shlenskaya V. I., Velskii N. K. Analytical chemistry of platinum metals. Moscow : Nauka, 1972. 616 p.
18. Petrov G. V., Kovalev V. N. Intensification of anion sorption of iridium with highly basic anionite AMP from sulfate solutions. Journal of Mining Institute. 2011. Vol. 189. pp. 310–313.
19. Petrov G. V., Greiver T. N., Belenky A. M., Boduen A. Ya., Kovalev V. N. Study of behavior of sulfate iridium complexes in sorption by ion-exchange resins. Izvestiya vuzov. Tsvetnaya metallurgiya. 2006. No. 6. pp. 34–38.

Полный текст статьи Sorption concentration of ruthenium from sulfuric solutions